2020 Ford F-150 Engine cooling Problems
- Complaints
- 11about this part
- Share
- 1%of 741 total for the year
- Median mileage
- 81,557miles
- Trend
- Not enough dataFewer than 15 complaints, too few for a reliable trend.
NHTSA recorded 11 complaints about the engine cooling of the 2020 Ford F-150, 1% of the 741 complaints for this model year. Where a mileage was given, the median is 81,557 miles.
Fewer than 15 complaints name this part, so treat the figures as a rough indication only.
Example complaints
Selected from NHTSA records; personal details are removed. They are consumer reports, not findings.
“The contact owns a 2020 Ford F-150. The contact stated that the seal underneath the vehicle was fractured nearby the exhaust. There were no warning lights illuminated. The vehicle was taken to the local dealer, where an unknown diagnosis was completed. The vehicle was not repaired. The manufacturer was not contacted. The failure mileage was approximately 75,000.”
NHTSA complaint #11607196, filed 2024-08, 75,000 miles“The contact owns a 2020 Ford F-150. The contact stated that the vehicle experienced excessive oil consumption and while operating the vehicle at lower RPM a rattling and pinging sound was coming from the engine compartment. Additionally, the check engine warning light was illuminated. The cause of the failure was not yet determined. The manufacturer and local dealer were notified of the failure, but no assistance was provided. The failure mileage was 75,000.”
NHTSA complaint #11559928, filed 2023-12, 75,000 miles“The contact called for her partner who owned a 2020 Ford F-150. The contact stated that the dashboard had warped near the passenger side's glove compartment when purchased. The dealer had been informed of the failure and informed the owner that the dashboard needed to be replaced. The vehicle was not repaired. The contact stated that while the vehicle was stopped and idling at a traffic light, the vehicle lunged forward causing the contact to aggressively depress the brake pedal, causing the vehicle to jerk abnormally. …”
NHTSA complaint #11636285, filed 2025-01, 81,557 miles“The contact owns a 2020 Ford F-150. The contact stated while driving at an undisclosed speed, the accelerator pedal was depressed; however, the vehicle failed to accelerate as intended. In addition, the check engine warning light illuminated, and the transmission shuddered. The vehicle was taken to the dealer, and the contact was informed that a tune-up was needed. The tune-up was performed; however, the failure reoccurred. The vehicle was taken back to the dealer where it was diagnosed with catalytic converter failure. …”
NHTSA complaint #11653158, filed 2025-04, 90,400 miles“The contact owns a 2020 Ford F-150. The contact stated that after the check engine warning light illuminated on two occasions, the vehicle was taken to the dealer, where the catalytic converters were replaced under warranty. The contact stated that the check engine warning light was intermittently illuminated. The vehicle was taken back to the dealer, where it was determined that one of the catalytic converters needed to be replaced. The contact was informed that the manufacturer would provide partial financial assistance for the repair. …”
NHTSA complaint #11769954, filed 2026-10, 30,000 milesRelated service bulletins
- 10254166Apr 24, 2024This article supersedes TSB 22-2260 to update the vehicle applications. Some 2018-2020 F-150 vehicles equipped with a 2.7L EcoBoost may exhibit an illuminated malfunction…
- 10254122Apr 15, 2024Some 2020-2024 F-150 and 2021-2024 Bronco vehicles equipped with a 2.7L or 3.0L EcoBoost engine may exhibit a ticking/tapping or rattle type noise from the top front cover area…
- 10251952Mar 6, 2024For 2015-2024 Ford and Lincoln vehicles equipped with turbocharged engines and customer concern of an engine oil leak, refer to Workshop Manual (WSM), Section 303-00 for oil leak…
- 10251951Mar 6, 2024Some 2011-2024 Mustang and F-150 vehicles equipped with a 5.0L engine may exhibit a tick tap and/or typewriter ticking noise at idle after an engine oil change. It is often…
- 10236688May 26, 2023Some 2021-2023 Ford and Lincoln vehicles equipped with a 2.7L or 3.0L engine may exhibit an upper engine thump/knock noise coming from the left cylinder head. This condition is…
- 10236037May 5, 2023Some 2017-2020 F-150 and 2018-2020 Expedition/Navigator vehicles built on or before 30-Nov-2019 and equipped with a 3.5L EcoBoost engine may exhibit a ticking/tapping or rattle…
- 10234137Apr 6, 2023Some 2020-2023 F-150 and 2021-2023 Bronco vehicles equipped with a 2.7L or 3.0L EcoBoost engine may exhibit a ticking/tapping or rattle type noise from the top front cover area…
- 10230798Jan 12, 2023Some 2015-2020 F-150 vehicles equipped with a 2.7L, 3.5L or 5.0L engine may require replacement of the long block engine assembly. New service kits have been released which…
- 10225455Oct 19, 2022Some 2019-2021 F-150 vehicles built on or before 04-Mar-2021 and equipped with a 5.0L engine may experience an illuminated malfunction indicator lamp (MIL) and diagnostic trouble…
- 10225451Oct 18, 2022Some 2018-2021 F-150 vehicles equipped with the 3.0L diesel engine may experience low oil pressure at idle after an oil change. This condition may be caused by a broken…
Engine cooling: other model years
| Year | Complaints | Share of year |
|---|---|---|
| 2025 | 1 | 1% |
| 2024 | 4 | 2% |
| 2023 | 1 | 0% |
| 2022 | 3 | 1% |
| 2021 | 19 | 2% |
| 2020 | 11 | 1% |
| 2019 | 62 | 5% |
| 2018 | 88 | 4% |
| 2017 | 70 | 5% |
| 2016 | 30 | 1% |
| 2015 | 25 | 1% |
| 2014 | 10 | 1% |
| 2013 | 20 | 1% |
| 2012 | 17 | 1% |
| 2011 | 33 | 2% |
| 2010 | 31 | 4% |
| 2009 | 10 | 3% |
| 2008 | 22 | 6% |
| 2007 | 41 | 8% |
| 2006 | 77 | 13% |
| 2005 | 111 | 10% |
| 2004 | 167 | 8% |
| 2003 | 69 | 16% |
| 2002 | 196 | 24% |
| 2001 | 234 | 19% |
| 2000 | 135 | 13% |
| 1999 | 219 | 21% |
| 1998 | 174 | 13% |
| 1997 | 529 | 19% |
| 1996 | 23 | 7% |
| 1995 | 71 | 11% |
| 1994 | 52 | 8% |
| 1993 | 52 | 9% |
| 1992 | 37 | 8% |
| 1991 | 17 | 6% |
| 1990 | 21 | 8% |
| 1989 | 13 | 6% |
| 1988 | 11 | 8% |
| 1987 | 9 | 10% |
| 1986 | 9 | 15% |
| 1985 | 4 | 14% |
| 1984 | 2 | 13% |
| 1983 | 3 | 30% |
Other parts of the 2020 Ford F-150
360 complaintsEngine
130 complaintsElectrical system
88 complaintsOther or unknown
88 complaintsVisibility (wipers, defrost, mirrors)
63 complaintsForward collision avoidance
24 complaintsBrakes
23 complaintsBody and structure
22 complaintsVehicle speed control
17 complaintsBack-over prevention (rear camera)
16 complaintsFuel system
14 complaintsLatches, locks and linkages
11 complaints
← All problems reported for the 2020 Ford F-150
About this data. Data from NHTSA (ODI) complaints, recalls, TSBs and investigations, updated Oct 27, 2026. Complaints are unverified consumer reports and may be duplicated or inaccurate.
To check a specific vehicle for open recalls, use its VIN at nhtsa.gov/recalls. Methodology