2020 Ford Mustang Body and structure Problems
- Complaints
- 6about this part
- Share
- 5%of 121 total for the year
- Median mileage
- 45,500miles
- Trend
- Not enough dataFewer than 15 complaints, too few for a reliable trend.
NHTSA recorded 6 complaints about the body and structure of the 2020 Ford Mustang, 5% of the 121 complaints for this model year. Where a mileage was given, the median is 45,500 miles. 2 of these say a crash was involved and 1 a fire, according to the filers.
Fewer than 15 complaints name this part, so treat the figures as a rough indication only.
Example complaints
Selected from NHTSA records; personal details are removed. They are consumer reports, not findings.
“While driving at about 75mph the passenger door unlocked and opened by itself. We got an door not closed warning light on the dash and the warning chime in addition the horn was blowing in intervals of 2 quick beeps and repeated until we were able to pull over and reclose the door. About 1 hour later same conditions the same thing happened on the drivers side. We have since discovered from the dealer that here is a campaign number of 21N10 for this issue. Holiman Ford of Maple Shade NJ took the car in right away.”
NHTSA complaint #11585018, filed 2024-04“The gas tank was only getting 10 gallons of gas and not 16 gallons like it was suppose to. We ended up running out of gas on a road trip with our two young daughters in the middle of the night on I-75. The gas tank said you had 100 miles to go before empty and then 3 miles later it would drop to 0 and you were running out of gas. This car was used in street racing which was late devulged to us after we found out that at 20,000 miles a whole new engine was put in without our knowledge when we purchased the vehicle . We took it to the dealer and they put a new fuel assembly unit in it. …”
NHTSA complaint #11520799, filed 2023-05“The contact owns a 2020 Ford Mustang. The contact stated that the engine warning light was illuminated. The vehicle was taken to the local dealer, where it was diagnosed and determined that the catalytic convertor and active grill shutter assembly needed to be replaced. The vehicle was not repaired. The manufacturer was contacted and referred to the NHTSA Hotline. The failure mileage was approximately 86,000.”
NHTSA complaint #11604661, filed 2024-07, 86,000 miles“The contact owns a 2020 Ford Mustang. The contact stated while driving at an undisclosed speed, the trunk wing spoiler detached and flew off the vehicle. The vehicle was taken to the dealer and the contact was advised that the trunk and the wing spoiler needed to be replaced. The vehicle was not repaired. The contact stated that the failure had occurred several times. In addition, the contact stated that during a previous failure, the trunk and the wing spoiler were both replaced. The first two failure occurrence and the trunk and the wing spoiler, were both repaired. …”
NHTSA complaint #11661488, filed 2025-05, 5,000 miles“This vehicle has been in an accident with damage exceeded $5000.00 (I have a Ford Dealerships estimate to prove damage on the vehicle has not been eepaired nor reported) Again, substantial, front drivers side, hood, wheel, breakline, door and underbody damage occurred to this vehicle. It was never reported to Carfax nor any online reporting agency. This vehicle is being resold with a 'clean' carfax because damage has never been reported.”
NHTSA complaint #11443811, filed 2021-12Related service bulletins
- 11029052Feb 24, 2026Ford and Lincoln vehicles equipped with wired keyless entry keypad systems and accessory wireless keyless entry keypad systems may or may not come with a wallet card containing…
- 10246072Nov 15, 2023Certain 2015 â 2021 Model Year Mustang Convertible Vehicles - Door Opens to Secondary Latch Position
- 10244797Oct 27, 2023This article supersedes TSB 21-2220 to update the model years affected and part list. Some 2018-2024 Mustang coupe vehicles may exhibit a sagging headliner or gap where the…
- 10235153Apr 4, 2023For 2000-2024 Ford and Lincoln vehicles, swapping a module from a vehicle for diagnosis purposes is likely to cause errors and is not recommended. It is also not recommended to…
- 10214761Jun 27, 2022Some 2015-2022 Mustang vehicles may exhibit a water leak onto the front carpet that originates from the either the left or right A-pillar. This may be due to a detached A-pillar…
- 10194436May 18, 2021Some 2020-2021 Mustang Shelby GT500 vehicles may exhibit a cracking on the hood inner panel. The crack is a cosmetic condition, not a structural concern. This may be due to a…
- 10183568Nov 10, 2020Some 2020 Mustang GT500 vehicles may exhibit a difficulty opening or closing the hood. This may be due to the hood pin assemblies sticking in place. To correct this condition…
- 10177863Jul 13, 2020This article supersedes TSB 19-2026 to update the vehicle model years affected. Some 2000 and newer Ford/Lincoln/Mercury vehicles equipped with aluminum body panels may exhibit…
- 10175895May 18, 2020Some 2013-2018 C-Max, 2013-2020 Escape/Fusion/MKZ, 2015-2018 Focus,2015-2019 MKC, 2015-2020 Edge/F150/Mustang, 2016-2018 MKX, 2016-2019 Explorer, 2017-2020 F-Super Duty…
Body and structure: other model years
| Year | Complaints | Share of year |
|---|---|---|
| 2024 | 6 | 7% |
| 2022 | 5 | 10% |
| 2021 | 1 | 2% |
| 2020 | 6 | 5% |
| 2019 | 9 | 6% |
| 2018 | 15 | 8% |
| 2017 | 41 | 15% |
| 2016 | 28 | 7% |
| 2015 | 45 | 10% |
| 2014 | 17 | 5% |
| 2013 | 8 | 3% |
| 2012 | 23 | 5% |
| 2011 | 10 | 2% |
| 2010 | 17 | 7% |
| 2009 | 6 | 3% |
| 2008 | 15 | 4% |
| 2007 | 51 | 8% |
| 2006 | 30 | 7% |
| 2005 | 56 | 8% |
| 2004 | 4 | 3% |
| 2003 | 4 | 3% |
| 2002 | 10 | 8% |
| 2001 | 6 | 3% |
| 2000 | 18 | 6% |
| 1999 | 9 | 4% |
| 1998 | 8 | 3% |
| 1997 | 5 | 3% |
| 1996 | 10 | 4% |
| 1995 | 19 | 3% |
| 1994 | 14 | 4% |
| 1993 | 6 | 6% |
| 1992 | 3 | 4% |
| 1991 | 2 | 3% |
| 1990 | 4 | 5% |
| 1989 | 8 | 7% |
| 1988 | 3 | 3% |
| 1987 | 1 | 3% |
| 1986 | 1 | 3% |
Other parts of the 2020 Ford Mustang
26 complaintsElectrical system
25 complaintsEngine
25 complaintsOther or unknown
22 complaintsBrakes
17 complaintsBack-over prevention (rear camera)
12 complaintsAir bags
8 complaintsFuel system
8 complaintsVisibility (wipers, defrost, mirrors)
5 complaintsForward collision avoidance
4 complaintsVehicle speed control
4 complaintsEngine cooling
3 complaints
← All problems reported for the 2020 Ford Mustang
About this data. Data from NHTSA (ODI) complaints, recalls, TSBs and investigations, updated Oct 28, 2026. Complaints are unverified consumer reports and may be duplicated or inaccurate.
To check a specific vehicle for open recalls, use its VIN at nhtsa.gov/recalls. Methodology